2015 Jeep Grand Cherokee

High pressure fuel pump failure Open

The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited i…

Desiccated Air Bag Inflator Rupture Open

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deploymen…

Seat Belt Retraction Closed

The Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate complaints alleging improper retraction of the front seat belts (driver or passenger) due to the plastic guide of the D-ring cracking in model year (MY) 2014 Jeep Grand Cherokee vehicles. The purpose of the investigation was to understand the scope, frequency and safety related consequence of the alleged defect. The subject co…

Active Head Rest Inadvertent Deployment Closed

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles. When ODI opened the investigation, ODI was aware of thirteen alleged injuries. A small number of Early Wa…

Vehicle rollaway, engine on Closed

On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA…

Powered vehicle rollaway Closed

The Office of Defects Investigation (ODI) opened Preliminary Evaluation PE15-030 on August 20, 2015,to investigate 14 complaints alleging incidents of rollaway after intended shifts to Park in Model Year (MY) 2014 and 2015 Jeep Grand Cherokees vehicles. The MY 2014-2015 Grand Cherokee vehicles are equipped with Monostable electronic ("E-shift") gearshift assemblies supplied by ZF Group (ZF). The E-shift system operat…

Software security vulnerability Closed

On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International. On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU securi…

False Positive Automated Braking Closed

On June 1, 2015, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE15-021 to investigate 9 complaints alleging incidents of unintended braking in model year (MY) 2014 Jeep Grand Cherokee vehicles, including 2 alleging incidents of full ABS braking. ODI expanded the scope to include MY 2015 Grand Cherokee vehicles and identified a total of 176 incidents in complaints provided by FCA or submitte…

Label

Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: Thi…

Engine

Issue: On certain vehicles equipped with a 3.0 L diesel engine, a problem with the engine tone wheel could cause a loss of signal to crankshaft position sensor. If this happens, the engine could stall and you may not be able to restart it. Note: Vehicles included in FCA recall W58 (Transport Canada recall 2020-371) are not part of this recall. Safety Risk: A sudden loss of engi…

Fuel System

Issue: On certain vehicles equipped with a 3.0 L diesel engine, the high-pressure fuel pump could fail. If this happens, you may notice a change in engine performance, a fuel leak, or a malfunction indicator lamp and/or service electronic throttle control tell-tale may turn on. This could also result in a sudden loss of engine power while driving. Safety Risk: A sudden loss of…

Engine

Issue: On certain vehicles equipped with a 3.0-L EcoDiesel engine, the exhaust gas recirculation (EGR) cooler could crack internally and leak. If this happens, a driver may notice a low coolant level or a heater that does not work properly. Safety Risk: A cracked EGR cooler could create the risk of an engine fire. Corrective Actions: FCA Canada will notify owners by mail and in…

Engine

Issue: On certain vehicles equipped with a 3.0 L diesel engine, a problem with the engine tone wheel could cause a loss of signal to crankshaft position sensor. If this happens, the engine could stall and you may not be able to restart it. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: FCA Canada will notify owners by mail and…

Other

Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk…

ENGINE AND ENGINE COOLING

Chrysler (FCA US, LLC) is recalling certain 2014-2019 Ram 1500 and 2014-2020 Jeep Grand Cherokee vehicles equipped with 3.0L Diesel engines. The crankshaft position sensor tone wheel may delaminate, causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.

Remedy: Dealers will update the powertrain control module software to maintain vehicle propulsion, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 3, 2023. Some owner notification letters were mailed October 31, 2023. The remaining owner notification let

FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP

Chrysler (FCA US, LLC) is recalling certain 2014-2020 Jeep Grand Cherokee, and 2014-2019 Ram 1500 vehicles equipped with 3.0L diesel engines. A high pressure fuel pump (HPFP) failure may introduce internal debris into the fuel system, potentially resulting in fuel starvation.

Remedy: Dealers will replace the HPFP, and inspect and replace, if necessary, additional fuel system components, free of charge. Interim notification letters informing owners of the safety risk were mailed July 21, 2022. Owner notification letters for were mailed for Jeep Grand Cherokee owners starting Janu

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Chrysler (FCA US LLC) is recalling certain 2014-2019 Jeep Grand Cherokee vehicles equipped with the 3.0L EcoDiesel engines. The Exhaust Gas Recirculation (EGR) cooler may crack and allow pre-heated vaporized coolant to enter the EGR system. This mixture may combust inside the intake manifold.

Remedy: FCA US LLC will notify owners, and dealers will replace the EGR cooler, free of charge. Dealers will also inspect and, as necessary, replace the intake manifold. Parts are not currently available. Owners were mailed an interim notification on December 21, 2021. A second notification will be mailed w

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Chrysler (FCA US LLC) is recalling certain 2014-2018 Ram 1500 and 2014-2016 Jeep Grand Cherokee vehicles equipped with 3.0L diesel engines. The crankshaft position sensor tone wheel may delaminate causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.

Remedy: FCA US will notify owners, and dealers will update the powertrain control module software to maintain vehicle propulsion by reading the camshaft position signal in the event that the crankshaft position signal is lost, free of charge. Owner notification letters were mailed on May 13, 2021. Owners ma

ELECTRICAL SYSTEM:SOFTWARE

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jee…

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise co

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

Accessible Technologies, Inc. (ATI) is recalling certain ProCharger Superchargers, model numbers AB037A-100, AB037A-100P, and A037A-100B, sold for installation on 2012-2017 Jeep Grand Cherokee SRT8 and SRT vehicles. The supercharger mounting bracket may contact and damage the ABS line, possibly resulting in a brake fluid leak.

Remedy: ATI will notify owners and will replace the supercharger brackets, free of charge. The recall began on December 12, 2017. Owners may contact ATI customer service at 1-913-338-2886.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Chrysler (FCA US LLC) is recalling certain model year 2012-2014 Dodge Charger and Chrysler 300 vehicles manufactured February 15, 2011, to November 27, 2014, and 2014-2015 Jeep Grand Cherokee vehicles manufactured July 16, 2012, to December 22, 2015. The affected vehicles, equipped with an eight-speed automatic transmission and a monostable gear selector, may not adequately warn the driver when dr…

Remedy: Chrysler will notify owners, and dealers will update the vehicle software to mitigate the risk of vehicle rollaway, free of charge. The recall began on June 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S27. Note: On October 19, 2016 C

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Grand Cherokee and Dodge Durango vehicles manufactured December 9, 2015, to January 14, 2016. In the affected vehicles, the left front brake caliper may crack due to being made from an incorrect material.

Remedy: Chrysler will notify owners, and dealers will inspect the front left brake caliper and depending on its casting date, replace it, free of charge. The recall is expected to begin on May 12, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S16.

SUSPENSION:REAR

Chrysler (FCA US LLC) is recalling certain model year 2015 Jeep Grand Cherokee and Dodge Durango vehicles manufactured June 12, 2015, to June 20, 2015. The affected vehicles may be equipped with rear lower control arms that may have been incorrectly heat treated. This may cause the rear lower control arm to fracture.

Remedy: Chrysler will notify owners, and dealers will inspect and if necessary replace the lower control arms, free of charge. The recall began July 29, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R38. Note: This supersedes Recall No. 15V-407.

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain netwo…

Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer

WHEELS,UNKNOWN OR OTHER,ENGINE

The tire pressure monitor system, the egr cooler. I had to change the egr the thermostat twice the engine the radiator the water pump and two oxygen sensors. The egr cooler is not recalled for my year but my truck was doin the same thing. The car still has a burning oil smell when the heat is on and the air don’t work

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

Recall 20V-475 / 23V-411 software patch was performed, but the underlying magnetic tone wheel defect has now physically failed, causing an active crankshaft position sensor error and stall hazard. While traveling 60mph the car stalled and went into limp mode with no prior warning. The vehicle has been diagnosed at a repair shop as a fault with the crankshaft…

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

I own a 2015 Jeep Grand Cherokee Summit 4x4 with the 3.0L EcoDiesel, with approximately 113,170 miles. The vehicle has experienced multiple intermittent episodes of “Service Electronic Throttle Control.” During the most recent episode, the vehicle briefly jerked/lurched forward and then experienced a significant loss of engine power/boost. I scanned the veh…

SEATS

The Active Head Restraint (AHR) deployed without a collision while I was slowing to a traffic signal. My vehicle was travelling approximately 5-7mph and slowing to a traffic signal when the Active Head Rest deployed, launching my head and trunk forward to the steering wheel. The Jeep Service Representative informed me that this is a well-known issue and …

STRUCTURE

My power lift gate closed unexpectedly and at a pace faster than usual. The lift gate came down on my head and compressed my neck. I have not tried the power lift gate again for fear of it breaking and not being able to be closed. The power lift gate has been sticking shut and not opening some times.

SEATS

I was driving home on the freeway from picking my kids up from school and all the sudden there was a loud crashing noise and my head was slammed forward and when I looked back to calm down my kids, I see that the headrest had just snapped and pushed forward, slamming me in the head

SEAT BELTS,SEATS

The passenger seat belt does not retract. Also my passenger head rest just came out 1 day.

AIR BAGS

Car was parked. When I returned the passenger head rest had popped. No accident.