2012 Jeep Grand Cherokee

Desiccated Air Bag Inflator Rupture Open

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deploymen…

Active Head Rest Inadvertent Deployment Closed

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles. When ODI opened the investigation, ODI was aware of thirteen alleged injuries. A small number of Early Wa…

Post 14V-391 Headliner Fires Closed

In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391. On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September…

Totally Integrated Power Module Failure Closed

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV’s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployme…

Headliner Fires Closed

On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in Augu…

Headliner Fires Closed

The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees. Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the veh…

Power steering hose failure Closed

The Office of Defects Investigation (ODI) analyzed complaint data provided by Chrysler as well as complaints submitted to ODI from consumers. ODI's analysis identified a total of 24 unique reports indicating power steering hose blow-offs resulting from a dislodged power steering cooler turbulator fin in some early production vehicles. According to Chrysler, a dislodged fin can occur when the turbulator is inserted in…

Label

Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: Thi…

Fuel System

Issue: On certain vehicles, the fuel pump relay could fail. A fuel pump relay failure can result in a no-start condition or cause a sudden loss of engine power while driving. Note: Vehicles that had a fuel pump relay replaced as part of a Transport Canada Recall No. 2014-386 (FCA Recall No. P54) or 2015-085 (R09) require a second repair under this recall. Safety Risk: A sudden…

Brakes

On certain vehicles, a brake booster shield may have been incorrectly installed as part of recall P14/2014-112. An incorrectly installed shield could be less effective in diverting water away from the brake booster, creating the possibility of corrosion allowing water to get inside. In a cold climate, water inside the brake booster could freeze limiting the braking ability of t…

Electrical

On certain vehicles equipped with electro-hydraulic power steering (“EHPS”), the alternator may fail suddenly. This could result in the engine stalling, causing a loss of motive power which could increase the risk of a crash as well as disable various vehicle safety systems, and could also cause a fire. Both issues could increase the risk of injury and/or damage to property. Co…

Electrical

On certain vehicles equipped with illuminated sun visor vanity mirrors with 120mm wiring, service repairs requiring removal of the sun visors and/or headliner may cause an electrical short circuit which could increase the risk of a fire causing injury and/or damage to property. Vehicles equipped with 120mm wiring that were previously repaired under recall 2014-275 will require…

Fuel System

This recall was replaced by Transport Canada Recall No. 2019-573 (FCA Recall No. V62). On certain vehicles, a fuel pump relay within the Totally Integrated Power Module (TIPM-7) could fail, causing the engine to stall or to fail to start. Engine stalling would result in a loss of motive power, which, in conjunction with driver reactions and traffic conditions, could increase th…

ELECTRICAL SYSTEM

Chrysler (FCA US LLC) is recalling certain 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles equipped with a 3.6, 5.7, or 6.4 liter engine and previously recalled under NHTSA Recall 14V530 or 15V115. The fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.

Remedy: Chrysler (FCA US LLC) will replace the affected fuel pump relay and related wire harness. Interim notices informing owners of the safety risk were mailed beginning December 19, 2019. Vehicles that experience a fuel pump failure will receive an interim repair. Owners will receive a second notice when

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

Accessible Technologies, Inc. (ATI) is recalling certain ProCharger Superchargers, model numbers AB037A-100, AB037A-100P, and A037A-100B, sold for installation on 2012-2017 Jeep Grand Cherokee SRT8 and SRT vehicles. The supercharger mounting bracket may contact and damage the ABS line, possibly resulting in a brake fluid leak.

Remedy: ATI will notify owners and will replace the supercharger brackets, free of charge. The recall began on December 12, 2017. Owners may contact ATI customer service at 1-913-338-2886.

SERVICE BRAKES

Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.

Remedy: Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T

INTERIOR LIGHTING

Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been re…

Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.

ELECTRICAL SYSTEM

Chrysler (FCA US LLC) is recalling certain model year 2012-2013 Jeep Grand Cherokee vehicles manufactured September 17, 2010, to August 19, 2013, and equipped with a 3.6, 5.7 or 6.4 liter engine, and 2012-2013 Dodge Durango vehicles manufactured January 18, 2011, to August 19, 2013, and equipped with a 3.6 or 5.7 liter engine. In the affected vehicles, the fuel pump relay inside the Totally Integr…

Remedy: Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM. The recall began on August 7, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R09. Note: This recall is an expansion of recall 14V-530.

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.

Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.

ELECTRICAL SYSTEM:WIRING

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, through December 11, 2013. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after a service repair is performed.

Remedy: Chrysler will notify owners, and dealers will inspect and repair any damaged wiring, and install a new sun visor that properly routes the wire, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P36.

SERVICE BRAKES

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.

Remedy: Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Chrysler Group LLC (Chrysler) is recalling certain model year 2012-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured October 11, 2011, through October 1, 2012. Under certain braking events, the Ready Alert Braking System (RAB) may result in the driver experiencing a hard brake pedal feel.

Remedy: Chrysler will notify owners, and dealers will update the ABS module software, free of charge. The recall began on April 3, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P05.

ENGINE AND ENGINE COOLING

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE T…

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

STEERING,SERVICE BRAKES,ENGINE

The engine / power cuts off with no warning causing steering to lock up to left & brakes lock up causing the vehicle to veer to the left and unable to use brake to stop vehicle. Happens randomly while driving which makes it unsafe to operate to drive.

ELECTRICAL SYSTEM

The alternator failed. It was the Safety Recall P60 (NHTSA 14V-634) remedy alternator, installed by an authorized FCA dealer when the recall was completed on 08/30/2021, as FCA confirmed in writing. On 09/24/2026, at 41,275 miles, the vehicle had no electrical power and would not start. An independent New York State registered repair facility diagnosed the …

UNKNOWN OR OTHER

Recall R71 was marked as completed on this vehicle, but the headliner caught fire exactly as described in the original defect narrative. SUV caught fire, blew up and took out four other vehicles and a parking structure.

FUEL/PROPULSION SYSTEM

Here’s the final version of your NHTSA complaint text — rewritten for clarity, precision, and compliance. You can copy and paste this directly into the “Description of the Problem” box on the NHTSA form.Recall Number: V62 – Fuel Pump RelayMy Jeep is under recall V62 for the fuel pump relay. Stellantis confirmed that the recall is active and that the remedy i…

ELECTRICAL SYSTEM

Alternator smoking. it is available for inspection. Filled interior of vehicle with smoke the engine stopped running while driving. Took to dealership for a 2nd sun visor recall and had them diagnose the smoking alternator. The voltage light came on just before the alternator started smoking

POWER TRAIN,ELECTRICAL SYSTEM

My 2012 Jeep Grand Cherokee suddenly was stalling, and would not re-start, especially when turning the steering. AAA Tech diagnosed as High Diode Ripple Voltage in the Alternator, damaging the Battery. Needed to Replace both Alternator and Battery at a cost of $1068. Car was recalled under T36, and the repair has a repeat failure again. Jeep Declined to r…

UNKNOWN OR OTHER,ENGINE

Problem was Oil Filter housing made of plastic. It was cracked and no warning light that oil had leaked out. Car SUDDENLY DECELERATED as I was merging into traffic on freeway causing vehicles coming up behind to brake rapidly including a semi truck which had been 200 yards back. I rolled onto shoulder with warning lights activated. Pure luck it was not a…

UNKNOWN OR OTHER

I was caught driving in a hailstorm when hail impacted and broke the panoramic sunroof of my vehicle. I understand that hail can break automotive glass and that the sunroof is constructed from safety glass. My concern is not that the glass broke, but how it shattered. When the sunroof failed, it fragmented into extremely fine particles and powdered glass. T…