2014 Ford Fusion

Pedestrian alert sounds Closed

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that…

Front Brake Jounce Hose Failures Closed

On August 8, 2022, the Office of Defects Investigation (ODI) opened this investigation based on 50 Vehicle Owner Questionnaires (VOQs) alleging front brake jounce hose ruptures on model year (MY) 2013-2018 Ford Fusion and Lincoln MKZ vehicles. A ruptured front brake hose results in a brake fluid leak. As a result, the driver may experience an increase in pedal travel and a reduction in the rate of deceleration, incre…

Desiccated Air Bag Inflator Rupture Open

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deploymen…

Door Latch Failures Closed

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture…

Steering Wheel Fastening Bolt Loosens Closed

On March 12th, 2018, Ford Motor Company submitted a Defect Information Report to NHTSA describing a defect in the steering wheel fastening system of approximately 1,301,986 model year (MY) Ford Fusion and Lincoln MKZ. On March 1, 2018, Ford discovered a design change that affected the MY 2014-2018 subject vehicles. The affected population are MY 2014-2016 Fusion and MKZ with manual and power adjust steering columns a…

Powertrain

Issue: On certain vehicles, the recall repairs completed by a Ford dealer during recall 18S07 (Transport Canada recall no. 2018-129) may not have been done correctly. As a result, a second repair is required. Note: This recall only affects vehicles equipped with a 1.0 L or 1.6 L engine and a manual transmission. On certain vehicles, repeated clutch slipping could cause the pres…

Brakes

Issue: On certain vehicles, the front brake hoses could fail and cause a progressive brake fluid leak. If this happens, the driver may experience a change in brake pedal feel and travel. This can cause reduced braking. Note: A brake fluid leak would cause the brake warning light to turn on. This recall doesn't affect models with a Hybrid engine. Vehicles repaired under Ford war…

Powertrain

Issue: On certain vehicles, the shift cable may detach from the transmission. This could cause the transmission not to shift gears when the shifter is moved. As a result, the transmission could be in a different gear than the gear shifter indicates. If a driver attempts to exit the vehicle while the transmission is not in Park, and the parking brake is not applied, the vehicle…

Structure

Issue: This recall is for a small number of cars that were sold in United States and imported to Canada. On these vehicles, the door latches could crack and fail due to exposure to high ambient temperatures. If this happens, a door may not properly latch when it is closed. As a result, the door could open while driving. Safety Risk: A door that opens while driving could create…

Steering

Issue: On certain vehicles, the bolts that attach the electric power steering assist motor to the steering gear may corrode and break. This could cause a loss of power steering assist. This recall applies to vehicles originally sold or currently registered in areas of heavy road salt usage (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & La…

Other

Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk…

POWER TRAIN:MANUAL TRANSMISSION

Ford Motor Company (Ford) is recalling certain 2015-2018 Focus and 2013-2016 Fusion vehicles previously repaired incorrectly under recall numbers 18V169 and 18V845. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.

Remedy: Dealers will update the software, free of charge. Additionally, dealers will inspect Focus vehicles and replace the clutch assembly as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 5, 2026. Additional letters will be sent once the remedy is avail

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.

Remedy: Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed June 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S12.

POWER TRAIN:SHIFT LINKAGE/CABLE/ROD

Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.

Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notificatio

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

Ford Motor Company (Ford) is recalling certain 2014-2015 Fusion, Lincoln MKZ, and 2015 Mustang vehicles originally sold or ever registered, in Texas, Louisiana, Mississippi, Alabama, Florida, Georgia, South Carolina, North Carolina, Virginia and Hawaii. Exposure to certain environmental conditions, such as high temperatures, high humidity, and salt air can cause the brake pedal bumper to corrode a…

Remedy: Dealers will replace the brake pedal bumpers and clutch pedal bumpers, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed on March 4, 2022. Owner notification letters were mailed on June 13, 2022. Owners may contact Ford customer service at 1-866-436-7

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latc…

Remedy: Ford will notify owners, and dealers will inspect the latch date codes to confirm if the repair was done correctly, and replace the side door latches if necessary, free of charge. Owners will also have the option to inspect their own vehicle's door latches and enter the date codes into a website to

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2014-2015 Fiesta, 2014-2016 Fusion and Lincoln MKZ vehicles sold, or ever registered in Alabama, Arkansas, Arizona, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, New Mexico, Nevada, Oklahoma, Oregon, South Carolina, Texas, Utah, Washington, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Is…

Remedy: Ford will notify owners, and Ford or Lincoln dealers will replace the side door latches, free of charge. The recall began September 21, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S15.

STEERING:ELECTRIC POWER ASSIST SYSTEM

Ford Motor Company (Ford) is recalling certain 2013-2016 Ford Fusion and Lincoln MKZ, 2015-2016 Ford Edge, and 2016 Lincoln MKX vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, We…

Remedy: Ford will notify owners, and dealers will replace the steering gear motor bolts and apply a wax sealer. If any of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began Oct

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT

Ford Motor Company (Ford) is recalling certain 2013-2016 Fusion vehicles equipped with 2.5 liter engines. The bushing that attaches the transmission shifter cable to the transmission may degrade over time and cause the bushing to detach from the transmission. The condition could allow the driver to move the shift lever to Park and remove the ignition key, while the transmission may not be in Park,…

Remedy: Ford will notify owners, and dealers will replace the shifter cable bushing, free of charge. The recall began September 10, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S16. Note: Owners are directed to use the parking brake until the recall re

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT

Ford Motor Company (Ford) is recalling certain 2013-2014 Ford Escape, and 2013-2016 Ford Fusion vehicles, equipped with six-speed automatic transmissions. The bushing that attaches the transmission shifter cable to the transmission may degrade over time and cause the bushing to detach from the transmission. The condition could allow the driver to move the shift lever to Park and remove the ignitio…

Remedy: Ford will notify owners, and dealers will replace the shifter cable bushing, free of charge. The recall began September 20, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S20. Note: Owners are directed to use the parking brake until the recall re

STEERING: STEERING WHEEL/HANDLE BAR

Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.

Remedy: Ford will notify owners, and dealers will replace the steering wheel bolt with a longer bolt, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S08.

POWER TRAIN:MANUAL TRANSMISSION

Ford Motor Company (Ford) is recalling certain 2013-2014 Ford Fusion vehicles equipped with a 1.6L GTDI engine and 6-speed manual transmission and 2015-2016 Ford Focus vehicles equipped with a 1.0L GTDI engine and 6-speed manual transmission. Also included are four 2017 Ford Focus vehicles that had clutch replacements with potentially affected parts. The clutch may fracture, resulting in damage to…

Remedy: Ford will notify owners, and dealers will update the Focus vehicles with software that detects and prevents prolonged clutch slip, and will replace the clutch, as necessary, free of charge. Owners of Fusion vehicles will have their clutch assembly replaced free of charge. The recall began August 3,

ENGINE AND ENGINE COOLING:ENGINE

Ford Motor Company (Ford) is recalling certain 2014 Escape, 2014-2015 Fiesta ST, 2013-2014 Fusion and 2013-2015 Transit Connect vehicles equipped with 1.6L GTDI engines. If the vehicle is started and driven with an insufficient level of coolant within the engine cooling system, the engine cylinder head may overheat, crack and leak oil.

Remedy: Ford will notify owners, and dealers will install a coolant level sensor and the supporting hardware and software, free of charge. Interim notices informing owners of the safety risk were mailed April 21, 2017. The recall began on January 5, 2018. Owners may contact Ford customer service at 1-866-43

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2014 Ford Fiesta, 2013-2014 Ford Fusion and 2013-2014 Lincoln MKZ vehicles. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.

Remedy: Ford will notify owners, and dealers will replace all four door latches, free of charge. The recall began May 1, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S16.

SEAT BELTS:FRONT

Ford Motor Company (Ford) is recalling certain model year 2013-2016 Ford Fusion vehicles manufactured November 2, 2012, to July 31, 2014, and 2013-2015 Lincoln MKZ vehicles manufactured November 14, 2012, to July 31, 2014. In the event of a crash, heat from the deployment of a seat belt pretensioner may cause a front seat belt anchor cable to fail.

Remedy: Ford will notify owners, and dealers will apply a protective coating to the seat belt cable, free of charge. The recall began May 16, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S42.

STEERING:ELECTRIC POWER ASSIST SYSTEM

Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Fusion and Lincoln MKZ vehicles manufactured February 3, 2012, to March 20, 2015, and 2015 Ford Edge vehicles manufactured February 26, 2015, to February 28, 2015, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New…

Remedy: Ford will notify owners, and dealers will apply sealer and replace the steering gear motor bolts as required. If one or more of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The re

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) notified the agency on April 23, 2015, that they are recalling certain model year 2013-2014 Ford Fusion and Lincoln MKZ vehicles manufactured July 1, 2012, to May 31, 2013, and 2012-2014 Fiesta vehicles manufactured February 1, 2012, to May 31, 2013. On April 30, 2015, Ford expanded the recall to cover an additional 119,567 vehicles, including certain model year 2011 Ford…

Remedy: Ford will notify owners, and dealers will replace all four door latches with an improved part, free of charge. Interim notifications were mailed to owners on June 5, 2015. The recall began on December 18, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain model year 2014-2015 Ford Fusion vehicles manufactured July 27, 2013, to October 31, 2014, 2015 Ford Fusion Hybrid vehicles manufactured February 24, 2014, to October 31, 2014, and 2015 Ford Fusion Energi vehicles manufactured July 14, 2014, to October 31, 2014. In the affected vehicles, the key may be able to be removed even while the transmission is…

Remedy: Ford will notify owners, and dealers will repair the vehicles, free of charge. The recall began on December 15, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C11.

SEAT BELTS

Ford Motor Company (Ford) is recalling certain model year 2013-2014 Ford C-Max vehicles manufactured January 19, 2012, to November 21, 2013; Ford Fusion vehicles manufactured February 3, 2012, to August 24, 2013; Ford Escape vehicles manufactured October 5, 2011, to November 1, 2013; and Lincoln MKZ vehicles manufactured April 25, 2012, to September 30, 2013. The coating on portions of the Restrai…

Remedy: Ford will notify owners, and dealers will replace the RCM, free of charge. Parts are not currently available. The recall began on May 26,2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S21.

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain model year 2013-2014 Ford Fusion and Lincoln MKZ vehicles manufactured August 15, 2012, through September 10, 2013, 2013-2014 Ford Escape vehicles manufactured June 5, 2012, through August 12, 2013, and 2013-2014 Ford C-Max vehicles manufactured from July 23, 2012, through May 28, 2013. The driver and passenger seatback assemblies may have been produc…

Remedy: Ford will notify owners, and dealers will replace the seatback, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14C03.

UNKNOWN OR OTHER

On XXX, while my 2014 Ford Fusion was moving, the left-front door latch failed and the door became unsecured. As a result, I partially fell from the moving vehicle. This was an actual occupant safety event and created a significant risk of serious injury. After the incident, I took the vehicle to Richmond Ford Lincoln for inspection and repair. On XXX, the …

SERVICE BRAKES

The contact owns a 2014 Ford Fusion. The contact stated that while driving 30 MPH, the vehicle entered limp mode and failed to accelerate as intended. The transmission ran poorly, making it difficult to merge, and the contact expressed concern regarding a potential crash. Following the failure, the hill brake assist turned off. The brake pedal bumper and sto…

POWER TRAIN

Transmission going out

ELECTRICAL SYSTEM,SERVICE BRAKES

The brake pedal switch pad was recalled and failed after being fixed and tripped the whole ABS system which caused the whole transmission to not shift and I didn’t have traction. My taillights stayed on 24/7 and I had to disconnect my battery. Ford did nothing

ELECTRICAL SYSTEM,SERVICE BRAKES

The brake pedal switch pad was recalled and failed after being fixed and tripped the whole ABS system which caused the whole transmission to not shift and I didn’t have traction. My taillights stayed on 24/7 and I had to disconnect my battery. Ford did nothing

AIR BAGS

Involved in collision between 35-45 at a speed of 35 to 45 mph. I had a car change lanes incorrectly causing me to rear end the vehicle. The front end of my car was crumpled in and mybairbags on my vehicle did not deploy as a result of the crash.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2014 Ford Fusion. The contact stated that the brake pedal was not sending the correct signal to the ABS. The "Hill Assist" option was not operational while driving on a slope and the brake lights remained illuminated, even when the brake pedal was not depressed. An independent mechanic was contacted and associated the failure with the brak…

UNKNOWN OR OTHER

I had a recall on my 2014 ford fusion se regarding powertrain control module software update. I took my vehicle in to Athens ford 6/8/26 to have this fixed then on Friday my car lost power while driving, would not go l, then when I cut it off & back on it was like it went in to failsafe or limp mode. I called Athens ford 5 times on Friday & got no answer, 3 …