2000 Ford Taurus

Speed control cable damage Closed

On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant. In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming par…

REAR COIL SPRING FRACTURE Closed

ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES). APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS. BECAUSE AIR LOSS FROM A REAR TIRE CAN RESULT IN CHANGE…

REAR COIL SPRING FRACTURE Closed

THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES. SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE. AN ANALYSIS OF THE VEHICLE OWNER QUESTIONNAIRES (VOQS) SUBMITTED TO ODI REVEALS THAT 42% OF THE COMPLAINANTS ALLEGE THAT TH…

FRONT SUSPENSION COIL SPRING FRACTURE Closed

ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES. AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141. MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE. ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHE…

BRAKE/ACCELERATOR PEDAL APPLICATION Closed

MS. RODMAN REPORTED THAT AFTER HER VEHICLE WAS INSPECTED FOR THE RECALL, HER MOTHER EXPERIENCED A SUDDEN ACCELERATION AND CRASHED THE SABLE INTO A LIGHT POLE. PREVIOUSLY NHTSA HAD CONDUCTED AN INVESTIGATION FOR THIS ISSUE (PE02-035) THAT RESULTED IN THE RECALL (02V-266) OF 369,000 MY 2000-2002 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE BRAKE AND ACCELERATOR PEDALS TO INSURE THAT THE SEPARATION BETWEEN THE PED…

BRAKE LIGHT SWITCH FAILURE Closed

FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078). RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078. ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES, FAILURES IN MY 2001-02 VEHICLES WITH ADJUST…

FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH Closed

THIS INVESTIGATION IDENTIFIED A TOTAL OF 427 REPORTS ALLEGING NON-DEPLOYMENT OF THE FRONTAL AIR BAGS. OF THE 427 REPORTS, TWO INCIDENTS (FATAL CRASHES) HAVE BEEN IDENTIFIED AS SEVERE FRONTAL CRASHES IN WHICH THE FRONTAL AIR BAGS DID NOT DEPLOY. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME. FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF…

FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH Closed

FORD MOTOR COMPANY HAS IDENTIFIED 260 REPORTS ALLEGING FRONTAL AIR BAG NON-DEPLOYMENT FOR ANY (SEVERITY) FRONTAL OR NEAR-FRONTAL CRASH ON MODEL YEAR 2000-2001 FORD TAURUS AND MERCURY SABLE VEHICLES. ADDITIONAL CRASH REPORTS ARE CONTAINED IN NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE. THE SINGLE ODI REPORT LISTED IN THE REPORT SUMMARY IS NHTSA'S SPECIAL CRASH INVESTIGATION'S CASE NO. CA00-020 THAT INVO…

BRAKE/ACCEL PEDAL SEPARATION Closed

Suspension

On certain vehicles, the front coil springs may fracture when operated in high corrosion areas (where salt is used on the roadways in winter). The potential for corrosion causing a spring to fracture increases with the number of kilometres and years in service on the vehicle. A fractured spring could move past the spring seat and contact a front tire causing a rupture resulting…

Lights And Instruments

On certain vehicles, a malfunctioning stop lamp switch and/or associated wiring may render the stop lamps inoperable or cause them to stay on all the time. If the switch and/or wiring fail in the open position, the brake lights will not activate and the driver will not be able to shift the vehicle out of park. If they fail in the closed position, the brake lights will remain on…

Other

On certain vehicles equipped with adjustable pedals, the manufacturing process of the subject Taurus adjustable pedal assembly resulted in variability in lateral pedal spacing ranging from 41mm to 85mm. Discussions with drivers of vehicles with adjustable pedals disclosed that some were unfamiliar with the feature. Decreased brake to accelerator pedal spacing may increase the r…

Other

Certain passenger cars, sport utility vehicles, and light and medium duty pickup trucks. A switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, smoke or, potentially, ignition of the plastic cover material. Switc…

Brakes

On certain vehicles, the adjustable pedal assembly may have excess grease that could potentially enter the stop lamp switch and contaminate the contacts. This could lead to a build up of carbon, and potentially a short circuit. A short circuit could either cause the stop lamps to remain on, or cause a loss of stop lamp function. Correction: Brake lamp switch will be replaced an…

Lights And Instruments

On certain vehicles, the headlamp switch knob may have been molded from a plastic material that is more brittle than the intended material. This material may be overstressed when the knob is installed on the switch, leading to a later fracture, and in some cases, separation of the knob from the headlamp switch. If this should occur, it may be difficult for the driver to activat…

SUSPENSION:FRONT:SPRINGS:COIL SPRINGS

ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSIO…

Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, T

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH.

Remedy: DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PADELS ARE BEING RECALLED IN ORDER TO ADJUST THE BRAKE AND ACCELERATOR PEDALS TO A MINIMUM OF 50 MM OF LATERAL SEPARATION. SIMULTANEOUS APPLICATION OF BOTH THE BRAKE AND ACCELERATOR PEDALS COULD RESULT IN AN INCREASE IN ENGINE RPM.

Remedy: OWNERS WILL BE INSTRUCTED AS TO THE PROPER WAY TO SET THE POSITION OF THE PEDALS AND TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE SPACING BETWEEN THE BRAKE AND ACCELERATOR PEDALS MEASURED. IF THE SPACING IS FOUND TO BE LESS THAN 50 MM, THE DEALER WILL ADJUST THE PEDALS TO INCREASE THE DISTANCE BET

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKEL…

Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE F

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. DUE TO THE USE OF INCORRECT MATERIAL BY A SUPPLIER, THE HEADLAMP SWITCH KNOB CAN FRACTURE AND SEPARATE FROM THE HEADLAMP SWITCH.

Remedy: DEALERS WILL REPLACE THE HEADLAMP SWITCH KNOB. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS. IF THE GREASE FROM THE ADJUSTABLE PEDAL ASSEMBLY ENTERS THE STOP LAMP SWITCH, IT CAN CONTAMINATE THE CONTACTS LEADING TO CARBON BUILD UP, AND POTENTIALLY, A SHORT CIRCUIT.

Remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH AND WIPE DOWN THE ADJUSTABLE PEDAL ASSEMBLY TO REMOVE EXCESS GREASE. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME S

EXTERIOR LIGHTING:BACK UP LIGHTS

VEHICLE DESCRIPTION: PASSENGER SEDANS WITH FACTORY OR DEALER-INSTALLED DECK LID SPOILERS WITH LED CENTER HIGH MOUNTED STOP LAMPS (CHMSL). VEHICLES PRODUCED WITH SPOILERS WERE MANUFACTURED FROM MARCH 1 THROUGH OCTOBER 31, 2000; AND VEHICLES WITH SPOILERS INSTALLED BY DEALERS WERE MANUFACTURED FROM JANUARY 1 THOROUGH DECEMBER 30, 2000. WITH THE IGNITION SWITCH IN THE START OR RUN POSITIONS AND THE H…

Remedy: DEALERS WILL INSTALL A JUMPER/RESISTOR ASSEMBLY AT THE SPOILER THAT PROVIDES AN ELECTRICAL RESISTOR TO GROUND AND CORRECTS THE CHMSL AND BRAKE-SHIFT INTERLOCK CONDITIONS. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AN

EQUIPMENT:OTHER:LABELS

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE "VEHICLE CAPACITY WEIGHT" AND "DESIGNATED SEATING CAPACITY" INFORMATION WAS NOT PRINTED ON THE SAFETY CERTIFICATION LABELS AFFIXED TO THESE VEHICLES. ON AFFECTED SABLE SEDAN VEHICLES, THE "VEHICLES CAPACITY WEIGHT" (AND ALSO THE LUGGAGE LOAD) INFORMATION PRINTED ON THIS LABEL IS INCORRECT - SABLE WAGON LUGGAGE LOAD WAS INCORRECTLY USED FOR THE SABLE SED…

Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENTAL LABEL WITH THE CORRECT INFORMATION, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL ADJACENT TO THE VEHICLE CERTIFICATION LABEL. OWNER NOTIFICATION BEGAN OCTOBER 20, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE

STEERING

Vehicle Has A Heavy Power Steering Fluid Leak!!! Will Be Taking It To The Shop To Diagnose The Concern!!! I Was Checking To See If There Were Any Campaigns Or Recalls Reported!!!

AIR BAGS

Someone pulled out in front of me as I was slowing down to make a left turn. I T-boned their vehicle while going 35mph, resulting in a total loss for my 2000 Ford Taurus. (This was in 2018 so it was not a new car). My driver steering wheel airbag DID NOT deploy. I was wearing my seat belt. I still have chest pains when I sneeze and cough, even 4 years later…

POWER TRAIN

WHEN I MAKE A LEFT TURN, MY TRANSMISSION DISENGAGES & MY ENGINE RPM'S INCREASE UNTIL I RECOVER FROM THE TURN.

VEHICLE SPEED CONTROL,SERVICE BRAKES,ENGINE

IT PRESENTED A SERIES OF MISSED FIRED AND OVER HEATING ON THE ROAD , AFTER DRIVING AROUND 150 MILES , THE ENGINE LEAKING OIL AND IT LOSS POWER MAKE IT ON SAFE TO DRIVE . THE AIR CONDITIONING SYSTEM IS ICED UP LIKE A FRIDGE AND LESS COOLING IN AN OVER WHOLE LOOK THE CAR NEED SAFETY CONTROL AND ALL OF THIS CAN CLEARLY SEEN ON THE CITY ROAD WAY .

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT THE HEADLIGHTS FAILED TO SHUT OFF, WHICH REQUIRED THE BATTERY CABLE TO BE DISCONNECTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT FELT THAT THE VEHICLE WAS UNSAFE TO DRIVE IN THE EVENT THAT THE DAY TIME RUNNING LAMPS, HIGH BEAMS, AND FOG LIGHTS SHORT OUT. THE DEALER WAS NOT CONTACT…

AIR BAGS

JUNE 2018 PASSENGER SIDE AIRBAG DEPLOYED WHILE BEING DRIVEN ON A CITY STREET BY MY GRANDDAUGHTER, NO THERE NO SIGNS OF A COLLISION. IT WAS TAKEN TO A MECHANIC.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE

PART OF THE ENGINE, TOP PORTION CLOSEST TO THE FIREWALL ON THE PASSENGER SIDE OF THE VEHICLE, CAUGHT ON FIRE WHILE I WAS DRIVING ON A CITY STREET NEAR MY RESIDENCE IN LANCASTER, CA. I NOTICED THE SMOKE EMITTING FROM UNDER THE HOOD WHEN I CAME TO A STOP AT THE STOP LIGHT.

AIR BAGS

TAKATA RECALL I CONTACTED THE LOCAL DEALERSHIP ABOUT THE UNSAFE AIRBAGS AND THEY SEEMED TO FEEL AS IF IT WAS NO BIG DEAL AND TOLD ME THAT THEY DID NOT HAVE THE PARTS TO FIX MY AIRBAGS.