2005 Ford Escape XLS

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT

Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissio…

Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-43

HYBRID PROPULSION SYSTEM

Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.

Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this

SUSPENSION:FRONT:WHEEL BEARING

The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, …

Remedy: Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.

SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.

Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.

Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

UNKNOWN OR OTHER

I bought a 2005 Ford escape the VIN number on the dash and the title do match however the ECU and the door jamb VIN [XXX] which is for a 2006 Ford escape 4 cylinder 2.3. the vehicle I bought should be a 6 cylinder with a 3.0 l the mechanic says mismatched VIN the dealership refuses to listen. About the vehicle on [XXX] drove it 30 miles then was able to cal…

ELECTRICAL SYSTEM

Odometer Fraud. The contact purchased a 2005 Ford Escape on November 25, 2025. The contact discovered a mileage and VIN discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the mileage was 199,500. The vehicle was taken to the dealer for a routine inspection, and the dealer informed the contact that during the diagnostic te…

SERVICE BRAKES

I had just started up my 05 Ford hybrid Escape reversed out of a parking space, applied my brakes and a loud warning noise went off, the ABS light & the Brake light went on, then I tried to brake while backing out of the parking stall. I had no brakes, petal went all the way to the floor. I shifted into drive to pull forward. The car wouldn’t stop petal just…

UNKNOWN OR OTHER

Front Subframe rusted out causing loss of steering and control. Car came to a complete skidded stop . The front wheel nearly came off. The subframe issue is the same problem that resulted in a recall of the 2001-2004 Ford Escape.

POWER TRAIN

The contact owns a 2005 Ford Escape. Upon starting of the vehicle, the contact placed the vehicle into drive(D); however, the vehicle failed to accelerate upon the depression of the accelerator pedal. The contact stated that prior to the failure, the check engine warning light illuminated and remained illuminated on the instrument panel. The contact stated w…

SUSPENSION

The right lower control arm separated from the subframe due to subframe rust. It caused loss of handling and rendered the car immobile. It was caused by a panic stop at a low speed. The car was towed to an independent garage where it is awaiting repair. Parts affected were the subframe, CV axle joint and the front fender (From the wheel hitting it when it br…

STEERING,SUSPENSION,STRUCTURE

Hello, The engine cradle subframe on my 2005 Ford Escape has completely rusted through on the right hand side where it attaches to the steering control arm. As I was driving the subframe broke which made it impossible to steer the car. This pulled my car off the road to the passenger side. Fortunately I was not injured. Having now researched this issue,…

UNKNOWN OR OTHER

The right back tire shock and spring mount broke right off