2001 Chevrolet Suburban

Brake line corrosion failure Closed

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues: Connecticut, Delaware, District of Columbia, Illinois…

Brake line corrosion failure Closed

The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines. DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehic…

CRANK POSITION SENSOR FAILURE - STALL Closed

IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000. ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PE…

CRANK POSITION SENSOR FAILURE - STALL Closed

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE06-016) ON MAY 4, 2006 BASED ON ELEVEN VEHICLE OWNER QUESTIONNAIRES (VOQS) AND EARLY WARNING (EWR) DATA ALLEGING SUDDEN ENGINE SHUTDOWN WHILE DRIVING AS A RESULT OF CRANK POSITION SENSOR FAILURES IN MY 2001-2002 GENERAL MOTORS C/K PLATFORM VEHICLES EQUIPPED WITH 8.1L ENGINES. IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY ODI, GENERAL…

PARKING BRAKE FAILURE Closed

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED. MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE. ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

UNWANTED LOW-SPEED ABS ACTIVATION Closed

IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379). GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REG…

OVERHEATED FUEL PUMP WIRING Closed

IN A LETTER DATED APRIL 14, 2005, GENERAL MOTORS (GM) NOTIFIED ODI THAT IT HAD IDENTIFIED A DEFECT RELATED TO MOTOR VEHICLE SAFETY IN APPROXIMATELY 316,508 MODEL YEAR (MY) 2000-01 1500 SERIES CHEVROLET SUBURBAN AND GMC YUKON XL VEHICLES (RECALL 05V-155). GM DETERMINED THAT SOME OF THESE VEHICLES WERE EQUIPPED WITH FUEL MODULE RESERVOIR ASSEMBLIES (MRAS) THAT CONTAIN FUEL PUMP WIRES AND/OR CONNECTORS THAT MAY OVERHEAT…

OVERHEATED FUEL PUMP WIRING Closed

THE FUEL PUMP WIRING AND CONNECTOR MAY OVERHEAT AND MELT A HOLE IN THE TOP OF THE FUEL PUMP MODULE. POSSIBLE CONSEQUENCES INCLUDE FUEL TANK LEAKAGE AND ENGINE STALL WITH NO RESTART. FOURTEEN OF THE 20 COMPLAINTS TO ODI ALLEGE FUEL TANK LEAKAGE, INCLUDING ONE THAT REPORTED THAT A FIRE DEPARTMENT WAS CALLED TO THE SCENE AFTER A "POOL" OF GASOLINE WAS DISCOVERED BENEATH THE VEHICLE. MOST OF THE ODI COMPLAINTS REPORT INC…

HYDRAULIC PUMP FAILRES Closed

GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999. SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES. THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004. ODI…

STEEL WHEEL RIM FRACTURE Closed

THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT. THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE. THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%. THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT…

ALLEGED FAILURE OF 2ND ROW SEATBELT ALR Closed

THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE. THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED. THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM. GM'S INSTRUCTIONS STATE FOR THE FINAL S…

THROTTLE STICKING CLOSED Closed

THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM) THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION. IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED. THE APPLICATION OF ADDI…

Engine

On certain vehicles equipped with an 8.1L engine, the crankshaft position sensor may fail. If the sensor operates intermittently, the Service Engine Soon (SES) light may illuminate and the vehicle may run rough. In addition, the engine may stall, and if so, may re-start immediately or after a cool-down period. If the sensor becomes inoperable permanently, the engine will quit r…

Electrical

Certain vehicles were built with fuel module reservoir assemblies that contain fuel pump wires and/or connectors that may overheat under certain operating conditions. Fuel pump wires that overheat may become exposed and result in one or more conditions; 1) If the ignition circuit wire is exposed and shorts to ground, the fuel pump fuse will blow, disabling the fuel pump and cau…

Brakes

Certain vehicles located in Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador may experience unwanted Antilock Brake System (ABS) activation and increased stopping distances during low-speed brake application (less than 16 km/h and greater than 6 km/h). This condition does not set any ABS codes nor does it illuminate the ABS warning…

Seats And Restraints

Certain vehicles fail to conform to CMVSS 209, seat belt assemblies. These vehicles have a condition where one or two sensors in the driver's and front seat passengers seat belt retractors may be inoperative. The seat belt retractors will lock when the belt webbing is extracted during a crash; however the mechanism that locks the seat belt retractor when the vehicle decelerates…

Seats And Restraints

Certain vehicles have an internal component in the 2nd and 3rd row outboard seat belt retractor that could be cracked. With repeated actuation of the locking mechanism, the crack could spread to the point where the seat belt would no longer lock. In a crash, increased occupant injury could result from the no-lock condition. Correction: Dealers will inspect the outboard seat bel…

Structure

Certain vehicles may have loose or missing rear wheelhouse plugs. Under certain operating conditions, exhaust gases can flow forward and accumulate in the rear wheelhouse. These exhaust gases could flow into the passenger compartment if the wheelhouse plug is missing or loose and may cause possible illness, unconsciousness or death. Correction: Dealers will inspect for loose or…

ENGINE AND ENGINE COOLING

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN 8.1L V8 ENGINE, THE CRANKSHAFT POSITION CAN OPERATE INTERMITTENTLY OR FAIL COMPLETELY. IF THE SENSOR OPERATES INTERMITTENTLY, THE SES LIGHT MAY ILLUMINATE AND THE VEHICLE MAY RUN ROUGH. THE ENGINE MAY STALL, AND IF SO, MAY RE-START IMMEDIATELY OR AFTER A COOL DOWN PERIOD.

Remedy: DEALERS WILL REPLACE THE CRANKSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.

FUEL SYSTEM, GASOLINE

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS AP…

Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, …

Remedy: DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SI

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

CERTAIN TRUCKS AND SPORT UTILITY VEHICLES WERE BUILT WITH FUEL MODULE RESERVOIR ASSEMBLIES THAT CONTAIN FUEL PUMP WIRES CONNECTORS MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.

Remedy: DEALERS WILL REMOVE THE FUEL TANK, AND REMOVE THE MODULE RESERVOIR ASSEMBLIES FROM THE TANK, AND INSTALL A NEW SERVICE KIT FREE OF CHARGE. AN INTERIM LETTER TO OWNERS WAS MAILED ON MAY 25, 2005. THE OWNERS WERE RE-NOTIFIED ON OCTOBER 19, 2005, SINCE PARTS ARE NOW AVAILABE. OWNERS MAY CONTACT CHEVROL

STRUCTURE

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096

SEAT BELTS:FRONT:RETRACTOR

VEHICLE DESCRIPTION: PICKUP AND UTILITY TRUCKS. SOME OF THESE VEHICLES HAVE AN INTERNAL COMPONENT IN THE OUTBOARD SEAT BELT RETRACTORS FOR THE 2ND AND 3RD ROW OF SEATS THAT COULD BE CRACKED. WITH REPEATED ACTUATION OF THE LOCKING MECHANISM, THE CRACK COULD SPREAD TO THE POINT SUCH THAT THE SEAT BELT WOULD NO LONGER LOCK.

Remedy: DEALERS WILL INSPECT THE OUTBOARD SEAT BELTS FOR SPECIFIC LOT NUMBERS AND REPLACE THE BELTS IF NECESSARY. GM IS ENCLOSING AN INSPECTION PROCEDURE FOR THE OWNERS TO USE OR THEY CAN HAVE THEIR DEALERS DO THE INSPECTIONS. OWNER NOTIFICATION BEGAN JULY 2, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHO

STRUCTURE:BODY

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.

Remedy: DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.

SERVICE BRAKES

The ABS and Brake lights illuminate as per GM recall 05v379000. This occurs each time the vehicle is driven. I purchased this vehicle on 12/6/2023 from Kyle's Kars which is a used car dealership in Slatington, PA. A warranty was not offered due to the age, however I did purchase a warranty from Car Shield. This repair would not fall under the warranty gui…

SERVICE BRAKES

this vehicle has a non-functioning parking brake. There was a recall in 2004 for 880,000 trucks and suv's. I have taken it to my garage twice but they cannot fix this problem because it is not fixable

SERVICE BRAKES

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING BEHIND HIS FATHER'S VEHICLE, THEY HAD APPROACHED A STOP AND ATTEMPTED TO DEPRESS THE BRAKE PEDAL. AS HIS FOOT WAS ON THE PEDAL, THE CONTACT COULD HEAR THE ABS MAKING AN ABNORMAL NOISE AS THE BRAKE PEDAL FAILED TO OPERATE AS NEEDED. DUE TO THE FAILURE, THE CONTACT HIT THE B…

SERVICE BRAKES,FUEL/PROPULSION SYSTEM

FUEL PUMP MAY FALTER OR FAIL; FUEL PUMP RELAY WAS NON-FUNCTIONAL, REPLACED IT; OTHER FUSES PASSED TESTING WITH METER; VEHICLE STARTED, WOULD NOT RUN MORE THAN A FEW MINUTES. NEW FUEL FILTER. GUY AT SERVICE STATION BANGED ON GAS TANK, AND IT WOULD START THEN RUN GREAT FOR A MINUTE, THEN WILL NOT RESTART. ORDERING A REPLACEMENT FUEL PUMP. BOUGHT THIS VEHICLE I…

SUSPENSION,SERVICE BRAKES

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHILE DRIVING AT LOW SPEEDS, THE VEHICLE EXPERIENCED INCREASED STOPPING DISTANCE WHEN BRAKING. THE VEHICLE WAS TAKEN TO COMMONWEALTH CHEVROLET (155 MARSTON ST, LAWRENCE, MA 01841, (978) 687-3000) WHERE IT WAS DIAGNOSED THAT THE DRIVER AND PASSENGER SIDE WHEEL BEARING ASSEMBLIES NEEDED TO BE REPLACED. THE VEHICL…

SERVICE BRAKES

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE WAS PUT ON A LIFT AND IT WAS DISCOVERED THAT THE BRAKE LINE WAS CORRODED, CAUSING A LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE CONTACT CALLED THE ED BOZARTH CHEVROLET DEALER (877-721-4901,…

SERVICE BRAKES

I WAS SLOWING FOR A STOP SIGN WHILE LEAVING A PARKING LOT WHEN THE STEEL REAR BRAKE LINE SPONTANEOUSLY SPLIT AND DUMPED ALL LINE PRESSURE. THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR, AND I ROLLED RIGHT INTO TRAFFIC BEFORE I WAS ABLE TO PUMP THE PEDAL ENOUGH TIMES TO STOP THE VEHICLE AGAINST A CURB. HAD I NEARED THE STOP SIGN 2 SECONDS EARLIER OR LATER, I WOU…

SERVICE BRAKES

I HAD A MAJOR BRAKE FAILURE THE OTHER DAY WHILE DRIVING. I HAD NO BRAKES, BUT I WAS ABLE TO STOP WITH THE EMERGENCY BRAKE. I HAD THE TRUCK TOWED TO THE MECHANIC AND THEY REPORTED THAT THE BRAKE FAILURE WAS DUE TO RUSTED BRAKE LINES.