2013 Toyota RAV4

Battery Hold Down Bracket Thermal Events Closed

The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE.PE21005 focused on replacement batteries in…

Electrical

Issue: On certain vehicles, the battery hold-down assembly may not properly secure certain 12 V aftermarket batteries. As a result, the battery could shift positions and cause the positive battery post to contact the hold down bracket. If this happens, there could be a short circuit. Safety Risk: A short circuit could create the risk of a fire. Corrective Actions: Toyota will n…

Electrical

Issue: This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. Note:…

Accessories

Issue: On certain vehicles, the hook and loop material used to attach the carpet to its underpadding may not be flame resistant. As a result, when it is tested alone, the loop fasteners do not meet the requirements of Canadian regulations. Safety Risk: As the carpet is always assembled, and the loop fasteners are very small, this problem does not create a safety risk. Correctiv…

Other

Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk…

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.

Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in la

TRAILER HITCHES

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.

Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.

ELECTRICAL SYSTEM

The system that failed is the 12-volt battery hold-down assembly and associated electrical infrastructure, exactly as described under NHTSA Safety Recall Campaign Number 23V-729 (Toyota Recalls 23TA13 / 23TB13). The vehicle is fully preserved in its post-fire state and is completely available for physical inspection upon request.Safety was severely compromis…

UNKNOWN OR OTHER

Toyota issues a Customer Support Program Notification regarding paint peeling on vehicles with factory applied Blizzard Pearl or Super White paint. The original expiration date was December 11, 2022 with secondary expiration being 10 years after first use, in my case October 14, 2023. Within the period I had 3 different parts of my car repainted due to peeli…

ELECTRICAL SYSTEM

Odometer Fraud. The contact purchased a 2013 Toyota RAV4. The contact stated that a mileage discrepancy was discovered after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 105,836; however, Carfax reported the mileage as 311,581.

UNKNOWN OR OTHER

I have a Blizzard White RAV4 2013 that I just bought the paint is peeling from roof and side doors. I called a Toyota dealer and they told me that they wouldn’t be able to paint it beacause the warranty of repainting had expired. In some parts of the car the pint is starting to bubble up . .

EXTERIOR LIGHTING

The other night driving home i notice that my headlights gotten dimmed. I turned on my fog lights so that i could see the road. after turning on my fog lights i had limited vision on the road. I feel that it's a safety concern that needs to be address so that i won't get into an accident. How should i proceed with the issue?

STRUCTURE

The vehicle has experienced premature and widespread paint peeling and clear coat failure on multiple body panels. The paint began deteriorating without impact, collision, or environmental damage and has progressively worsened over time. This condition is consistent with a known manufacturing defect affecting certain Toyota vehicles, which Toyota acknowledg…

ELECTRICAL SYSTEM

Odometer Fraud. The contact purchased a 2013 Toyota Rav4. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of the purchase, the mileage was 89,704. At the time of the vehicle registration, it was discovered that the mileage was 251,351.

STRUCTURE

The contact owns a 2013 Toyota Rav4. The contact stated that large pieces of paint had separated from the hood and contacted the front windshield while driving, creating a visibility hazard for the driver. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contact…