2014 Hyundai Santa FE

Hyundai and Kia ABS Module Fires Open

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and di…

Loss of Motive Power Closed

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the s…

Engine Fires Closed

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles.  During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to eng…

Throttle control system vulnerabilities Closed

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantr…

Non-crash Vehicle Fires Closed

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Hyundai Sonata and Santa Fe vehicles equipped with Theta II and Lambda II engines (approximately 1.3 million vehicles). ODI also…

Non-crash Vehicle Fires Closed

In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition. CAS s…

Scope and Timeliness Closed

NHTSA opened Recall Query (RQ) 17-004 to investigate the timeliness and scope of Hyundai’s Theta II GDI engine recalls (Recall Nos. 15V-568 and 17V-226), and Hyundai’s compliance with reporting requirements. On November 23, 2020, the Agency entered into a Consent Order with Hyundai to administratively resolve NHTSA’s assertions of violations of law in connection with RQ17-004. NHTSA’s assertions included that Hyundai…

Label

Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safet…

Brakes

Issue: On certain vehicles, brake fluid could leak into the control module for the antilock brake system (ABS) and cause it to short circuit. Note: This recall replaces recall R0246 (Transport Canada recall number 2023-527). For the Sonata model, only the Sonata Hybrid model is affected by this recall. Safety Risk: A short circuit could create a fire risk, even while the vehicl…

Brakes

This recall was replaced by Transport Canada Recall No. 2024-080. Issue: On certain vehicles, brake fluid could leak into the control module for the antilock brake system (ABS) and cause it to short circuit. Safety Risk: A short circuit could create a fire risk, even while the vehicle is parked and turned off. Corrective Actions: Hyundai will notify owners by mail and advise yo…

Brakes

Issue: Hyundai is conducting a special service campaign that provides anti-corrosion treatment to certain underbody components. Over time, components under the vehicle, including brake lines could corrode. If this happens, a brake line could fail and leak. A brake fluid leak can result in reduced braking. Safety Risk: Reduced braking can cause an extended stopping distance and…

Structure

On certain vehicles, the cable between the actuating lever for the secondary hood latch and the secondary latch may become corroded over time. This could cause the secondary hood latch to remain in the open position when the hood is closed. If the vehicle were to be driven with the primary hood latch disengaged, or primary hood latch is released while driving, the secondary hoo…

Tires

Certain vehicles equipped with Continental Crosscontact LX tires in P235/65R17 size, tire sidewall ply cords may have been damaged. This could cause a sidewall bulge and/or gradual air loss, which would result in ride vibration or irregular wear. Continued operation could also lead to a loss of tread or rapid loss of air pressure, resulting in tire failure. Tire failure could c…

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can res…

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

TIRES:SIDEWALL

Hyundai is recalling certain model year 2014 Santa Fe vehicles manufactured November 5, 2013, through November 15, 2013, and equipped with P235/65R17 103T Continental Crosscontact LX tires. The tires may have a damaged sidewall.

Remedy: Hyundai notified dealers to suspend sales of affected Santa Fe Sport vehicles equipped with the P235/65R17 103T tires, and replace them with alternative tires. All affected vehicles were remedied prior to retail sale. Owners may contact Hyundai Customer Care Center at 1-800-633-5151.

AIR BAGS

I request that NHTSA review what I believe is a misleading Hyundai warranty extension involving the Occupant Classification System (OCS/ODS), part of the air bag system. Around Mid May 2026, my air bag warning light began illuminating intermittently. I waited because I needed to save up the cash. Around June 2026, Hyundai mailed me a Warranty Extension Noti…

ENGINE

We are the original owner of a 2014 Hyundai Santa Fe. The vehicle is experiencing issues from internal engine oil consumption caused by a manufacturing defect in the GDI powertrain. In 2023, while driving under normal operating conditions, the vehicle began severely jerking, shuddering and hesitating during acceleration. This hesitation and sudden drop in po…

ENGINE

My car was in shop for Smog inspection and failed. Mechanic told me that the most likely reason was that the engine has issues related to failing crankshaft position sensor which triggered the check engine light. He further explained that the engine with this condition will have abnormal oil consumption. My experience is that is exactly what I wondered. No s…

ENGINE

Driving to work at 0730 on 20 may, i put my foot down to accelerate from 40mph and nothing happened, i tried again thinking foot placement and the engine died. All ligjts went out, engine turned off and i free coasted for 100 -150yards. Once stopped i mangaed to get the hazard lights on, and get out the vehicle. I was 30yards from traffic lights on a 3 lane …

SERVICE BRAKES

My insurance company said I have an urgent Recall on my vehicle. Recall # 251 ABS fuse replacement. NHTSA# 23V651000. I would like this replaced.

ENGINE

My engine failed and was diagnosed as needing to rebuilt or replaced by the dealership. During the pandemic it was hard to get parts so they rebuilt it. At first it was missed diagnosed because it was a 3.3l V6 and only the 4 cylinder engines were on recall. I had check engine lights on all the time. I paid for repairs that only masked the problem for a s…

ENGINE

While driving at approximately 70MPH on the highway, my 2014 Hyundai Tucson Limited suddenly locked up with no warning lights, no noise and no prior symptoms. The engine completely seized, causing immediate loss of power. I was barely able to coast off the highway exit to a final stop on the feeder shoulder, in a desolate area. The vehicle has always been…

VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM

The engine has been running rough for awhile and emissions light came on. My car was having problems accelerating, 2 years ago the light came on but didn’t stay on so the dealer couldn’t diagnose problem.