2003 Mini Cooper Base

STEERING:ELECTRIC POWER ASSIST SYSTEM

BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.

Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Own

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

SUSPENSION:REAR:SHOCK ABSORBER

ON CERTAIN VEHICLES, THE LOWER SCREW CONNECTION OF THE REAR STRUTS TO THE CHASSIS MAY FAIL. THE HEAD (TOP) OF THE SCREW SECURING THIS CONNECTION MAY BREAK. THE REMAINING PORTION OF THE SCREW WILL STILL HOLD THE STRUT IN PLACE.

Remedy: DEALERS WILL REPLACE THE LOWER SCREW CONNECTION OF THE REAR STRUTS. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.

STEERING

The contact owns a 2003 Mini Cooper. The contact stated that while operating the vehicle, the steering wheel was difficult to turn in either direction. The contact stated that the steering wheel malfunctioned, making the steering wheel easy to turn, causing severe oversteer while making a turn in either direction. The contact stated that the failure was due …

STEERING

68k miles on a 2003 mini cooper s and the power steering pump is whining. I feel as if this may be really early for it to be needing to be replaced.

STEERING

The contact owns a 2003 Mini Cooper. The contact received notification of NHTSA Campaign Number: 15V660000 (Steering); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the stee…

STEERING,ELECTRICAL SYSTEM,VISIBILITY/WIPER

No air or blower or heat to defog windshield. Water in driver-side foot well. Power steering intermittent fault. Engine continues running and panel gauge lights remain on with ignition off and key removed.

TIRES

The contact owns a 2003 Mini Cooper S equipped with Falken Tires, Tire Line: Sincera SN250 A/S, Tire Size: 235/45R17, DOT Number: FMHR3120. The contact stated that while washing the vehicle, he noticed that a bubble had developed on the front driver’s side tire. The contact was concerned for his safety while driving the vehicle. The contact stated that he ro…

ELECTRICAL SYSTEM,SEATS,SERVICE BRAKES

i Purchased the car in Dover Pa . INspection sticker had same milage as on car so i shoulda knew he slapped a sticker on . drove 150 miles dash lit ip like chrismas tree. 1st thing left window wont work , then left lock wont work had to lock from passenfger dide. then door wont open at all . have to get ou t passenger door . know that wont open have to put …

STEERING

My 2003 Mini Cooper was affected by the 2015 electrohydraulic steering assistance recall. Mini did the repair at 79, 322 miles in 2016. In November 2021, at 98, 000 miles, the car began having intermittent power steering loss. The power steering might disappear for under a minute, or it might return for mere seconds. There is no warning when the power ste…

TIRES

While driving on I-81 to NY state, I experienced serious tire vibration followed by tire loss of air. All tires were checked for proper tire inflation before trip. The service center in which I ended up in said that the tire belts had separated and caused the rapid tire deflation.