2002 Mini Cooper Base

STEERING:ELECTRIC POWER ASSIST SYSTEM

BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.

Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Own

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

POWER TRAIN:MANUAL TRANSMISSION:FLOOR SHIFT ASSEMBLY

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE TRANSMISSION SHIFT CABLE CONNECTS THE GEARSHIFT LEVER IN THE VEHICLE INTERIOR TO THE SHIFT LINKAGE ON THE TRANSMISSION. IT IS POSSIBLE FOR THE SHIFT CABLE TO DETACH FROM THE TRANSMISSION SHIFT LINKAGE WHILE THE DRIVER IS ATTEMPTING TO CHANGE GEARS. IF THE CABLE DETACHES FROM THE SHIFT LINKAGE, GEAR CHANGES WILL NO LONGER BE …

Remedy: DEALERS WILL INSPECT THE SHIFT CABLE AND, IF NECESSARY, INSTALL A RETAINING CLIP OVER THE END OF THE SHIFT CABLE TO PREVENT IT FROM DETACHING FROM THE TRANSMISSION. OWNER NOTIFICATION BEGAN AUGUST 6, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND D

EQUIPMENT:OTHER:LABELS

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS.' THE STANDARD REQUIRES THAT THE RELATIONSHIP BETWEEN THE TIRE SIZE AND MAXIMUM TIRE PRESSURE BE INDICATED ON THE VEHICLE'S TIRE INFORMATION LABEL. THIS RELATIONSHIP IS NOT PRESENT.

Remedy: OWNERS WILL BE PROVIDED WITH NEW TIRE INFORMATION PLACARDS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT MINI AT 1-866-275-6464.

ELECTRICAL SYSTEM,AIR BAGS,SEATS

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intac…

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't have any issues.

STEERING

The contact owns a 2002 Mini Cooper S. The contact stated that while driving approximately 45-55 MPH, the steering wheel seized. There was no warning light illuminated. The vehicle was coasted to the side of the road. The contact restarted the vehicle and continued driving normally. The vehicle was not taken to the dealer or an independent mechanic. The vehi…

AIR BAGS

Unoccupied passenger side airbags; all front & backseat bags deployed after passenger side tires hit pothole on road. Pieces of interior, including decorative plastic, interior light covers were projected across cabin & hit me. I had no idea what had happened. Car shut off shortly after incident. It was night, I was sitting in middle of my lane, unable to s…

UNKNOWN OR OTHER

MY MINI COOPER NEEDS RECALL WORK DONE. I AM IN BILLINGS, MT AND 392 MILES FROM THE CLOSEST CERTIFIED PLACE TO GET IT REPAIRED. I CAN'T TRAVEL THAT FAR IN A 2002 VEHICLE WITH HIGH MILES DURING A PANDEMIC. I AM A SENIOR CITIZEN AND HAVE ISSUES THAT DO NOT ALLOW ME TO TRAVEL THAT FAR. I AM STUCK WITH A VEHICLE THAT MAY HAVE A POTENTIAL STEERING ISSUE WITH NO WA…

STEERING

SO I BOUGHT A 2002 MINI COOPER LESS THAN A YEAR AGO AND IT CURRENTLY HAS 74K MILES AND ATTEMPTING TO PULL INTO A PARKING SPOT AT THE GROCERY MY STEERING GOES COMPLETELY OUT WHILE I WAS TRYING TO TURN INTO MY SPOT AND RIPPED OFF A BLACK MOLDING THAT GOES OVER THE FRONT PASSENGER WHEEL AND A SIGNIFICANT DING AND SCRATCH.

STEERING

THE VIN # OF MY 2002 MINI COOPER S WAS NOT INCLUDED IN THE RECALL FOR THE ELECTROHYDRAULIC STEERING FAILURE OF 2002 - 2005 MINI COOPER S BUT I AM EXPERIENCING THE EXACT ISSUE OUTLINED IN THIS RECALL. THE STEERING IS INCREDIBLY HARD TO TURN WHEN PARKED, AS WELL AS WHILE DRIVING. I NOTICED THAT THE RECALL HAD ABOUT 339 COMPLAINTS AND ROUGHLY 85,000 VEHICLES …

STEERING,ENGINE

PURCHASED THIS CAR USED WITH LOW MILES. SHORTLY AFTER PURCHASE I NOTICED THE STEERING ON MY VEHICLE GOT A LITTLE HARDER TO STEER, DIDN'T THINK TO MUCH ABOUT IT. THEN THE RADIATOR FAN WOULD NOT TURN OFF WHEN THE VEHICLE WAS OFF. TOOK THE CAR IN TO TWO DIFFERENT MECHANICS TO FIND THE PROBLEM. FOUND OUT IT WAS THE POWER STEERING PUMP WENT OUT CAUSING THE COO…