Recall 06V222000 · manufacturer campaign 002
Electrical System — Gem · reported 21 Jun 2006 · 27,350 vehicles potentially affected
What's wrong
ON CERTAIN 2 AND 4 PASSENGER, SHORT AND LONG BED LOW SPEED VEHICLES, THE 12 VOLT OUTPUT FROM THE AUXILIARY CARD CIRCUIT BOARD (A DC VOLTAGE TO DC VOLTAGE CONVERTER) MAY BECOME INOPERATIVE AND RESULT IN LOSS OF HEADLAMP, TAIL LAMP AND TURN SIGNAL LAMP FUNCTIONS.
The risk
A LOSS OF HEADLAMPS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH. IF THERE IS A LOSS OF TAIL LAMP OR TURN SIGNAL LAMP FUNCTION, A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED OR THAT THE VEHICLE IN FRONT IS TURNING, A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
The fix
DEALERS WILL REPLACE THE AUXILIARY CARDS, INSTALL A SPLASH/SPRAY PROTECTION, AND ADJUST THE DASH SEAL FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS MAY CONTACT GLOBAL ELECTRIC AT 888-871-4367.
GEMCAR RECALL NO. 002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Vehicles covered by this recall
Whether a particular car is affected and still unrepaired depends on its VIN — a model year being listed does not mean every car of that year is included. Check any VIN free on CarLogs, or at nhtsa.gov/recalls.
Is this car's recall fixed?
Recall repairs are free at any franchised dealer, for the life of the vehicle. A CarLogs report shows the recall status for a specific VIN as reported by the manufacturer — whether it's open or repaired, and whether the fix is available yet.
Source: NHTSA Office of Defects Investigation recall database. Look up another campaign →