Recall 07V548000
Structure › Body › Roof And Pillars — Cottrell · reported 3 Dec 2007 · 68 vehicles potentially affected
What's wrong
ON CERTAIN CAR HAUL TRAILERS THAT ARE EQUIPPED WITH ROOFS THAT RAISE AND LOWER, THE ROOFS ARE ATTACHED TO A RAISING/LOWERING MECHANISM BY ROUND TUBES THAT ARE WELDED TO THE ROOF. THERE ARE 4 TUBES WELDED TO EACH ROOF AND 2 ROOFS PER EACH COMPLETE PIECE OF EQUIPMENT. THE BASE MATERIAL AROUND THE WELDED CONNECTION MAY EXPERIENCE A FATIGUE FAILURE DURING HIGH MILEAGE OPERATION.
The risk
SHOULD FAILURE OCCUR ON ALL FOUR LIFT POINTS, THE ROOF MIGHT SEPARATE FROM THE TRAILER INCREASING THE RISK OF A CRASH TO FOLLOWING VEHICLES.
The fix
COTTRELL OR A REPAIR FACILITY AUTHORIZED BY COTRELL WILL ADD AN ADDITIONAL WELD PASS AROUND THE ROOF LIFT TUBE, INSTALL AN INNER AND OUTER GUSSET TYING THE ROOF INTO THE ROOF LIFT TUBE FREE OF CHARGE. THE RECALL BEGAN PRIOR TO NOVEMBER 21, 2007. ALL OWNERS HAVE BEEN CONTACTED.
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Vehicles covered by this recall
Whether a particular car is affected and still unrepaired depends on its VIN — a model year being listed does not mean every car of that year is included. Check any VIN free on CarLogs, or at nhtsa.gov/recalls.
Is this car's recall fixed?
Recall repairs are free at any franchised dealer, for the life of the vehicle. A CarLogs report shows the recall status for a specific VIN as reported by the manufacturer — whether it's open or repaired, and whether the fix is available yet.
Source: NHTSA Office of Defects Investigation recall database. Look up another campaign →