2004 Ford F-150 Lariat
1FTPW14524KD61376
Vehicle history report for the 2004 Ford F-150 Lariat (VIN 1FTPW14524KD61376). Black, pickup, 5.4L 8-cyl 300 hp, gasoline. 112,618 mi reported. Registered in Nc. 16 NHTSA recall campaigns for this model year. Unlock full title, salvage, lien & accident history.
Should you buy it? Worth a look — but negotiate
Weighed from safety recalls, known problems and market price.
- 16 recall campaigns exist for this model year. Check this VIN on NHTSA.gov to confirm the repairs were done.
- Owners most often report visibility trouble on this model — inspect it closely.
- The listed price of $11,100 is above the typical $3,300–$10,400 range for this model — strong room to negotiate.
- Lower mileage than typical for the year.
💵 A fair offer is around $6,614 (typical range $3,300–$10,400). Start a little below and leave room for anything the inspection turns up.
Full vehicle history report
Everything below is in the paid report for VIN 1FTPW14524KD61376, compiled live from NMVTIS and licensed providers the moment you unlock it. Not every vehicle has every record type — the report shows what is on file, and says so when nothing is. The 16 recall campaigns for this model year are shown further down.
📜 Title & ownership
- Title statusClean, salvage, rebuilt, junk, flood or lemon — from the national title database (NMVTIS)🔒
- Title brand historyEvery brand ever applied, by state, with what each one means🔒
- Title & registration recordsHow many times it has been titled, where, and the years-per-owner pace🔒
- Decode consistency checkThe provider's decode cross-checked against ours — a mismatch is a cloned-VIN warning sign🔒
🛞 Odometer
- Odometer timelineEvery reported reading with its date and state, drawn as a timeline🔒
- Rollback checkFlags any reading that goes backwards🔒
- Miles per yearThis car's pace against the US average🔒
💥 Damage, loss & theft
- Total-loss recordsInsurance total-loss declarations, with the reporting insurer type and date🔒
- Salvage & junk-yard recordsSalvage, junk and auction dispositions, including export flags🔒
- Theft screenActive and recovered theft records🔒
- Accident indicatorsDamage events reflected in title data (NMVTIS does not carry police crash reports)🔒
- Flood-exposure checkTitle activity in a disaster area soon after a major flood or hurricane🔒
💰 Liens & value
- Liens, impounds & exportOpen liens with the lender, tow/impound and export records🔒
- Market value for this exact carRetail adjusted for its mileage and state, trade-in, loan value, auction low/avg/high and retail by condition🔒
- DepreciationDrop from original MSRP, yearly rate and a one-year projection🔒
- Sticker vs dealer invoiceWhat it cost new, and what the dealer paid🔒
🧰 Factory warranty & equipment
- Remaining warrantyBasic, powertrain and rust coverage left, estimated from the first title date and odometer🔒
- Standard equipment & coloursWhat this trim came with from the factory, and the colours it was offered in🔒
🚨 Recalls on this VIN
- Per-VIN recall statusWhether each campaign has been repaired on THIS car, remedy availability, do-not-drive and stop-sale flags, dealer labour time🔒
At a glance
Vehicle identity & specifications
📋 All factory specifications on file6 more fields from the manufacturer's VIN record (NHTSA vPIC)
⚙️ Engine, fuel & battery
📐 Body, chassis & dimensions
🛡️ Safety & driver assistance
🏭 Manufacturing & other
Values are as reported by the manufacturer for this VIN pattern; blank or "not applicable" fields are omitted.
What's a 2004 Ford F-150 worth?
What comparable 2004 Ford F-150 vehicles are listed for — a quick gut-check before you negotiate.
Is the seller's price fair? Get this exact VIN's current market value — retail, trade-in & loan value — in the full report.
See this car's exact value →MPG & running costs
U.S. EPA fuel-economy estimates for the 2004 Ford F-150 with this engine.
Source: U.S. EPA / DOE fueleconomy.gov. The EPA lists 9 versions with this engine; combined is shown as a range and the other figures are averages. Actual mileage varies with trim and driving conditions.
Estimated 5-year cost to own
A rough guide to what running a 2004 Ford F-150 costs over five years and 75,000 miles.
How this is estimated: fuel is the U.S. EPA annual cost at 15,000 miles a year. Depreciation compares today's typical asking price for this model year ($6,614) with the same model 5 model-years older ($2,539), from CarLogs listing data. Not included: insurance, maintenance, repairs, taxes, registration and finance costs. Treat it as a comparison guide, not a quote.
Dimensions & weight
Manufacturer-reported figures for the 2004 Ford F-150 — ranges cover the 22 body / drivetrain versions on record. Source: Transport Canada vehicle specifications via NHTSA.
Investigations & service bulletins
NHTSA defect investigations 4
Fuel Tank Strap Failure Due to Corrosion Closed
One or both of the steel straps holding up the fuel tank and attaching it to the truck frame can corrode and fail (break or separate). If one strap fails, the tank may tilt and drop and possibly contact the road surface. If both straps break, the entire tank may drop to the road. If either failure occurs while the vehicle is being driven, contact with the road can abrade the tank and create a hole from which gasoline…
NHTSA #EA11006 · Fuel System, Other, Fuel System, Gasoline · opened May 2011 · closed Aug 2011Inadvertent airbag deployment Closed
ODI opened this investigation based on reports of inadvertent airbag deployment. Data provided by Ford indicated that the airbag clockspring jumper wire, which is situated inside the steering wheel assembly, was installed in a manner that would allow it to rub (abrade) against a sharp metal edge on the nearby horn plate. Because the horn plate is electrically grounded the abrasion of an airbag wire on the sharp edge…
NHTSA #EA10001 · Air Bags · opened Jan 2010 · closed Apr 2011CNG REGULATOR LEAK Closed
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF COMPLAINT REPORTS, DISCUSSIONS WITH COMPLAINANTS AND FIELD AND TECHNICAL DATA PROVIDED BY FORD. THE SUBJECT VEHICLES ARE 1/2 TON PICKUP TRUCKS AND ARE NATURAL GAS VEHICLES (NGV) THAT ARE FUELED BY GASOLINE OR COMPRESSED NATURAL GAS. THE AGENCY HAS RECEIVED REPORTS ALLEGING IMPROPER OPERATION OF THE NATURAL GAS FUEL PRESSURE REGULATOR ALLOWING RELEASE OF…
NHTSA #PE08063 · Fuel System, Other · opened Oct 2008 · closed Feb 2009SPARK PLUG EJECTION FROM CYLINDER HEAD Closed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES. ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECT…
NHTSA #DP05005 · Engine And Engine Cooling · opened Sep 2005 · closed Jan 2006An investigation means NHTSA is examining a possible defect — it is not a recall, and many close without one.
Manufacturer service bulletins 150
Technical notes the manufacturer sent to dealers about known issues and fixes. Useful to mention to a mechanic — they are not recalls and repairs may not be covered. Showing the 10 most recent of 150.
For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a diffe…
Bulletin SSM 51536 · Structure · Apr 2023This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accomp…
Bulletin TSB 20-2233 · Structure · Jul 2020This SKU is an Oil Dipstick. The customer communication requested return of unsold inventory to inspect the dipstick tube. The dipstick tube inner diameter may be small enough that it prevents installation of the OE dipstick.
Bulletin DOR-N3Z7B-03 · Engine And Engine Cooling · Feb 2020Some 2002-2008 F-Super Duty, F-150 and Mark LT vehicles may exhibit concern during or after programing the VSM. The programming may fail or vehicle symptoms such as inoperative door locks, dome lamps, door ajar indicators or auto lamps may occur after successf…
Bulletin SSM 48157 · Electrical System · Sep 2019Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Pro…
Bulletin TSB 19-2026 · Structure · Feb 2019Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Pro…
Bulletin TSB 19-2026 · Structure, Equipment · Feb 2019Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft rolle…
Bulletin SSM 47331 · Engine, Equipment · Jun 2018The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these P…
Bulletin SSM 46085 · Engine And Engine Cooling, Engine · Sep 2016SOME 2004-2014 F-150 AND 2006-2008 MARK LT VEHICLES EQUIPPED WITH FOUR-WHEEL DRIVE (4WD) MAY EXHIBIT NOISY OR ENGAGED FRONT HUBS WHEN OPERATING IN TWO-WHEEL DRIVE (2WD) MODE. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION.
Bulletin TSB16-0108 · Power Train · Aug 2016Safety recall 11S21 - Fuel tank strap fracture - requests for recall service action
Bulletin TSB160073 · Fuel System, Gasoline · Apr 2016Source: NHTSA Office of Defects Investigation, listed for the F-150. Model-year data, not specific to one car.
Canadian recalls 5
Transport Canada recall campaigns for the 2004 Ford F-150. Relevant if the car was first sold in, or imported from, Canada.
Other
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk…
Transport Canada #2019420 · Aug 2019Fuel System
On certain 1997-2003 F-150, 2004 F-150 Heritage, 1997-1999 F-250, and 2002-2003 Lincoln Blackwood vehicles that were originally sold in or are currently operated in areas of heavy road salt usage during winter months (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador), the fuel tank straps could corrode and fail. This could allow the…
Transport Canada #2011281 · Aug 2011Airbag
On certain vehicles, the airbag clockspring jumper wire may be oriented in a way that allows contact with the lower horn mounting plate. In this position the wire insulation may chafe, exposing bare copper, and creating the potential for a short circuit. Should this occur, the airbag warning lamp will illuminate, indicating service is required. In some instances, the driver's a…
Transport Canada #2011073 · Feb 2011Fuel System
Certain vehicles may have a fuel tank with a depression at the seam between top and bottom halves of the tank (not visible from outside the fuel tank). If a depression is large enough, fuel may permeate the fuel tank wall resulting in a fuel odour, illumination of the "Service Engine Soon" indicator light, or a fuel leak. A fuel leak in the presence of an ignition source could…
Transport Canada #2004317 · Sep 2004Fuel System
On certain vehicles, localized depressions in the fuel tank wall at the seam between the top and bottom halves of the tank may allow fuel to permeate resulting in a fuel odour, and/or a Malfunction Indicator Lamp (MIL) illumination. Correction: Dealer will replace the fuel tank.
Transport Canada #2004141 · Apr 2004Source: Transport Canada Motor Vehicle Safety Recalls Database.
About the Ford F-150
The Ford F-Series is a series of light-duty trucks marketed and manufactured by the Ford Motor Company since model year 1948 as a range of full-size pickup trucks—positioned between Ford's Ranger and Super Duty pickup trucks. Alongside the F-150, the F-Series also includes the Super Duty series, which includes the heavier-duty F-250 through F-450 pickups, F-450/F-550 chassis cabs, and F-600/F-650/F-750 Class 6–8 commercial trucks.
From Wikipedia, licensed CC BY-SA 4.0. Describes the model line in general, not this model year specifically.
Safety recall campaigns 16
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY,…
Remedy: FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRA
NHTSA Campaign #11V385000 · manufacturer #11S21 · 29/07/2011AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUI…
Remedy: FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECAL
NHTSA Campaign #11V107000 · manufacturer #11S18 · 23/02/2011EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
NHTSA Campaign #09E025000 · 11/05/2009EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
NHTSA Campaign #09E012000 · 07/04/2009EXTERIOR LIGHTING:HEADLIGHTS
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy: SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
NHTSA Campaign #07E089000 · 25/10/2007EXTERIOR LIGHTING:HEADLIGHTS
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy: SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
NHTSA Campaign #07E080000 · 25/09/2007EXTERIOR LIGHTING:HEADLIGHTS
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy: EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
NHTSA Campaign #07E075000 · 14/09/2007EQUIPMENT:ELECTRICAL
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Remedy: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
NHTSA Campaign #07E066000 · 28/08/2007VEHICLE SPEED CONTROL
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 20
NHTSA Campaign #07V336000 · manufacturer #05S28 · 03/08/2007EXTERIOR LIGHTING
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
NHTSA Campaign #06E064000 · 17/07/2006EXTERIOR LIGHTING
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Remedy: AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
NHTSA Campaign #06E060000 · 29/06/2006FUEL SYSTEM, GASOLINE
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
NHTSA Campaign #06E056000 · 13/06/2006EXTERIOR LIGHTING:HEADLIGHTS
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy: SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
NHTSA Campaign #06E052000 · 12/06/2006EXTERIOR LIGHTING:HEADLIGHTS
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Remedy: ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
NHTSA Campaign #06E023000 · 13/03/2006FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
NHTSA Campaign #04V443000 · manufacturer #04S21 · 13/09/2004FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
NHTSA Campaign #04V200000 · manufacturer #04S14 · 26/04/2004These are NHTSA recall campaigns for this model year, last checked 15 Oct 2026. They don't show whether this particular car has had the repair done — check this VIN on NHTSA.gov or ask a franchised dealer. Recall repairs are done at no charge.
We'll email you the moment a new safety recall is issued — no spam, unsubscribe any time.
Common problems & what to inspect
Based on all 2,036 owner complaints filed with NHTSA for the 2004 Ford F-150, here are the most-reported problem areas — and what to check before you buy.
💥 75 involved a crash 🔥 40 involved a fire 🚑 74 reported injuries
🔍 Test wipers, washers, defrosters and all mirrors. Check the windshield for cracks and any camera/sensor for fogging or faults.
🔍 Drive through every gear: watch for slipping, hard or delayed shifts, and shudder. Check for transmission/driveline leaks and noises.
🔍 Check coolant level and color, look for leaks, and confirm the engine reaches normal temperature without overheating.
🔍 Brakes should feel firm and quiet — no grinding, pulsing or pulling. Check for an ABS light and uneven pad/rotor wear.
🔍 Listen for clunks over bumps, check the car sits level, and look for uneven tire wear and worn shocks or struts.
🔍 Inspect for rust, fresh undercoating, mismatched paint, uneven panel gaps and any sign of prior collision or frame repair.
Pre-purchase checklist
- Match the VIN on the dash, door jamb and title — they must be identical.
- Cold-start the engine; listen for knocks and check for blue or white exhaust smoke.
- Test-drive through all gears at low and highway speed — no slipping, shudder or pulling.
- Confirm every warning light clears at startup (none should stay on).
- Check fluids — oil, coolant, transmission — for level, color and leaks.
- Look underneath for rust, fresh undercoating or signs of collision repair.
- Always get an independent pre-purchase inspection from a trusted mechanic.
Owner complaints 2036
Complaints filed with NHTSA by owners of the 2004 Ford F-150.
AIR BAGS
Vehicle was in an accident with major front and damage and none of the airbags deployed
Crash · NHTSA ODI #11764667AIR BAGS,SEAT BELTS
The contact owns a 2004 Ford F-150. The contact stated that the seatbelt pretensioners for all seats failed, and the frontal airbags for the driver seat and front passenger seat were inoperable. The seatbelt warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with faulty seatbelt pretensioners. A dealer was con…
NHTSA ODI #11749297UNKNOWN OR OTHER
Rear-end. The rear drivers side tire fell off while driving on a side street. With no noise or wobble or evidence of a problem. 2 days earlier my family and I were going 70 on an express way. Upon shops inspection the bearing was no longer working but wheel kept rolling, it egged out the housing of the axle shaft and heated up that point of axle and snapped …
NHTSA ODI #11710026ELECTRICAL SYSTEM,AIR BAGS,UNKNOWN OR OTHER
There is a recall on this vehicle
NHTSA ODI #11706348AIR BAGS,SEAT BELTS
My Teenage daughter was in a car accident and the airbags did not deploy and her seatbelt did not lock , and smashed into her steering wheel.
Crash · 1 injured · NHTSA ODI #11690826ELECTRICAL SYSTEM,SERVICE BRAKES,VISIBILITY/WIPER
Electrical malfunction with fuses , problems with brake light, engine light and air bag light . Some fuses blown out after brake light fuse popped wipers don't work at all air bog turns on and off every day not sure why
NHTSA ODI #11668789SEAT BELTS,UNKNOWN OR OTHER
The vehicle rolled and killed the occupant because the roof caved in. The shoulder portion of the seat belt did not hold the occupant (only the lap portion) and the occupant was partially ejected out of the rear of the cab. The vehicle was inspected and purchased by State Farm insurance since the vehicle was totaled. The 2000's Ford F-150s have roofs that ar…
Crash · NHTSA ODI #11659523ENGINE AND ENGINE COOLING,ENGINE
The contact owns a 2004 Ford F-150. The contact stated that while driving at undisclosed speeds, the vehicle shuddered and failed to accelerate while the accelerator pedal was depressed. The check engine warning light was illuminated. The contact pulled over to the shoulder of the roadway and was able to restart the vehicle. The contact scanned the vehicle w…
NHTSA ODI #11647392+ 2028 more complaints on record.
