2002 Mazda MPV ES

VEHICLE SPEED CONTROL:CABLES

ON CERTAIN MINIVANS EQUIPPED WITH CRUISE CONTROL, THE CRUISE CONTROL ACTUATOR CABLE MAY BE BROKEN DUE TO INSUFFICIENT STRENGTH (GROUP 1). ALSO INCLUDED ARE CERTAIN 2000-2001 MINIVANS EQUIPPED WITH CRUISE CONTROL BUILT BETWEEN MARCH 31, 1999 AND MARCH 31, 2001, THAT HAVE HAD THE CRUISE CONTROL REPAIRED AND POSSIBLY HAD A DEFECTIVE CABLE INSTALLED DURING THAT REPAIR (GROUP 2).

Remedy: DEALERS WILL REPLACE THE ACTUATOR CABLE. OWNER NOTIFICATION FOR VEHICLES INVOLVED IN GROUP 1 BEGAN ON JULY 7, 2004. OWNER NOTIFICATION FOR VEHICLES INVOLVED IN GROUP 2 BEGAN ON SEPTEMBER 10, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.

EXTERIOR LIGHTING:FOG LIGHTS

ON CERTAIN MINI VANS AND PASSENGER VEHICLES, THE SOCKET HOLDER IN THE FOG LIGHTS IS INSTALLED IN THE LAMP CASING USING PRESSURE. DURING OPERATION OF THE FOG LIGHT, THE HEAT FROM THE BULB CAN EXPAND THE SOCKET HOLDER. THE EXPANSION CAN FORCE THE SOCKET HOLDER REARWARD. AFTER REPEATEDLY BEING SUBJECT TO THIS EXPANSION, IF THE FOG LIGHT IS ALSO SUBJECTED TO VIBRATION DURING VEHICLE OPERATION, THE …

Remedy: DEALERS WILL INSTALL A SPRING TO PREVENT THE SOCKET HOLDER FROM SEPARATING FROM THE LAMP CASE. OWNER NOTIFICATION BEGAN ON JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTA

EQUIPMENT:OTHER:LABELS

CERTAIN MINI VANS FAIL TO COMPLY TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." AN INCORRECT GROSS AXLE WEIGHT RATING (GAWR) WAS INDICATED ON THE CERTIFICATION LABEL.

Remedy: OWNERS WILL BE MAILED ACCURATE CERTIFICATION LABELS AND INSERTS FOR THE OWNER'S MANUAL. OWNER NOTIFICATION BEGAN JUNE 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MAZDA AT 1

EXTERIOR LIGHTING:FOG LIGHTS

ON CERTAIN MINI VANS EQUIPPED WITH FRONT FOG LIGHTS,THE FOG LIGHT BULB SOCKET MAY HAVE BEEN INSTALLED IMPROPERLY.

Remedy: DEALERS WILL INSPECT THE INSTALLATION CONDITION OF THE FOG LIGHT BULB ASSEMBLY, AND REPAIR IT WHEN NECESSARY. OWNER NOTIFICATION BEGAN MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME

ENGINE

TL* THE CONTACT OWNS A 2002 MAZDA MPV. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE HESITATED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WOULD ALSO NOT ACCELERATE PROPERLY AND SHOOK WHILE IDLING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE COIL PACK FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACT…

SEAT BELTS

THE DRIVERS SEATBELT CLASP OR BUCKLE REFUSES TO ACCEPT THE STEEL TAB, AND WILL NOT LOCK. *TR

ENGINE

TL* THE CONTACT OWNS A 2002 MAZDA MPV. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHO COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,000.

VEHICLE SPEED CONTROL

TL* THE CONTACT OWNS A 2002 MAZDA MPV. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE ACTUATOR CABLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 04V234000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 150,000.

POWER TRAIN

TRANSMISSION FAILED, COMPLETELY DISENGAGED. NO WARNING. HAD TO BE TOWED. REQUIRED A $2500.00 COMPLETE OVERHAUL. VERY LOW MILES ON THIS VEHICLE, ALWAYS PROPERLY MAINTAINED. *TR

AIR BAGS

2002 MAZDA MPV. CONSUMER WRITES IN REGARDS TO VEHICLE AIR BAG LIGHT BEING ON. *SMD THE CONSUMER WAS INFORMED HIS VEHICLE IDENTIFICATION NUMBER, WAS NOT INCLUDED IN THE RECALL.

POWER TRAIN

DRIVING ON HIGHWAY WITH MY FAMILY WHEN MY MPV WOULDN'T SHIFT SO I COULD PASS A TRUCK. THEN IT STARTED TO LOSE SPEED. WOULD DEPRESS GAS PEDAL AND THE ENGINE WOULD REV BUT NO SPEED. HAD TO PULL OVER TO BREAKDOWN LANE WHICH BECAME A VERY DANGEROUS SITUATION. WE ARE LUCKY WE DIDN'T CAUSE AN ACCIDENT. MPV WOULD NOT WORK IN DRIVE, REVERSE, 3 OR 2 GEARS. WE WE…

AIR BAGS

TL* THE CONTACT OWNS A 2002 MAZDA MPV. WHILE TRAVELING 45 MPH THE VEHICLE CRASHED INTO THE SIDE OF ANOTHER VEHICLE. NONE OF THE AIRBAGS DEPLOYED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT INSPECTED FOR THE AIR BAG FAILURE OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 172,000. UPDATED 07/06/12 *BF